The Project Gutenberg eBook of Home-made cider vinegar

This ebook is for the use of anyone anywhere in the United States and most other parts of the world at no cost and with almost no restrictions whatsoever. You may copy it, give it away or re-use it under the terms of the Project Gutenberg License included with this ebook or online at www.gutenberg.org. If you are not located in the United States, you will have to check the laws of the country where you are located before using this eBook.

Title: Home-made cider vinegar

Author: Walter G. Sackett

Release date: December 26, 2023 [eBook #72394]

Language: English

Original publication: Fort Collins, Colorado: Agricultural Experiment Station

Credits: Produced by Joyce C. Hersh, from a scan of a copy in the University of Illinois Agricultural Library.

*** START OF THE PROJECT GUTENBERG EBOOK HOME-MADE CIDER VINEGAR ***

[Page 1]

Bulletin 192         November, 1913

The Agricultural Experiment Station

OF THE

Colorado Agricultural College

HOME-MADE CIDER VINEGAR

By WALTER G. SACKETT

PUBLISHED BY THE EXPERIMENT STATION

FORT COLLINS, COLORADO

1913

[Page 2]

The Agricultural Experiment Station

FORT COLLINS, COLORADO

THE STATE BOARD OF AGRICULTURE

Term

Expires

HON. F.E. BROOKS

Colorado Springs,

1915

HON. J.S.CALKINS

Westminster,

1915

HON. J.C.BELL

Montrose,

1917

HON. WILLIAM HARRISON

Clifton,

1917

HON. CHAS. PEARSON

Durango,

1919

HON. R.W. CORWIN

Pueblo,

1919

MRS. J.B. BELFORD

Denver,

1921

HON. A.A. EDWARDS

Fort Collins,

1921

GOVERNOR E.M. AMMONS, Ex-Officio

PRESIDENT CHAS. A. LORY, Ex-Officio

L.M. TAYLOR, SECRETARY

J.S. JONES, TREASURER

EXECUTIVE COMMITTEE IN CHARGE

A.A. EDWARDS, Chairman

J.S. CALKINS

E.M. AMMONS

STATION STAFF

W.P. HEADDEN, A.M., Ph.D.

CHEMIST

C.P. GILLETTE, M.S., Entomologist

DIRECTOR

G.H. GLOVER, M.S., D.V.M.

VETERINARIAN

W.G. SACKETT, B.S.

BACTERIOLOGIST

ALVIN KEYSER, A.M.

AGRONOMIST

J.O. WILLIAMS, B.S.A., U.S. expert-in-charge

HORSE BREEDING

E.P. SANDSTEN, Ph.D.

HORTICULTURIST

B.O. LONGYEAR, B.S.

BOTANIST

G.E. MORTON M.L., B.S.A.

ANIMAL HUSBANDSMAN

E.B. HOUSE, B.S. (E.E.), M.S.

IRRIGATION ENGINEER

V.M. CONE, B.S.

IRRIGATION INVESTIGATIONS

R.E. TRIMBLE, B.S.

ASSISTANT IRRIGATION INVESTIGATIONS

P.K. BLINN, B.S., ROCKY FORD

ALFALFA INVESTIGATIONS

EARL DOUGLASS, M.S.

ASSISTANT CHEMIST

S. ARTHUR JOHNSON, M.S.

ASSISTANT ENTOMOLOGIST

L.C. BRAGG

ASSISTANT IN ENTOMOLOGY

J.W. ADAMS, B.S., Cheyenne Wells

AGRONOMY ASSISTANT, DRY FARMING

ELWOOD D. ROOD, A.B.

ASSISTANT CHEMIST

W.W. ROBBINS, M.A.

ASSISTANT BOTANIST

PAUL S. JONES, B.S.

ASSISTANT IRRIGATION INVESTIGATIONS

RALPH L. PARSHALL, B.S.

ASSISTANT IRRIGATION INVESTIGATIONS

JAMES D. BELL, B.S.

ASSISTANT IRRIGATION INVESTIGATIONS

OFFICERS

CHAS. A. LORY, LL.D.

President

C.P. GILLETTE, M.S.

Director

L.M. TAYLOR

Secretary

MARGARET MURRAY

Executive Clerk

[Page 3]

HOME-MADE CIDER VINEGAR

By Walter G. Sackett.

In driving through the fruit-growing sections of the United States, one cannot fail to be impressed with the fact that thousands of bushels of apples and other fruit are allowed to go to waste annually just because it is too much trouble to gather it up and make some use of it. This is particularly true during a season when prices are low owing to an overproduction. Such a practice would be condemned, most certainly, by any commercial firm, and rightfully so, as a most extravagant waste and far removed from any principle of scientific management. Talk with any captain of industry, and he will invariably tell you that the largest profits in his business accrue from the complete utilization of the waste products.

Indifference to the needs of others and ignorance of the latent possibilities in this second grade fruit are largely responsible for the fruit grower’s short-sightedness. He is apt to forget that there are a few more than ninety-three million others in this country who are dependent upon him for orchard products such as cider, apple butter, jelly and vinegar, all of which could be made from this fruit which he permits to rot unnoticed under the trees. Could he only be shown the roll of greenbacks or catch the glitter of the gold which would represent his actual net return from the complete utilization of this unnecessary waste, rotten apples, wormy apples, green apples and everything would be cleaned up the next time we should pass by his orchard.

In spite of the fact that thousands of gallons of white wine vinegar, which has never been near a wine press, are produced yearly by a purely chemical process from alcohol, there is still a market for good, old-fashioned, apple cider vinegar. The genuine article will never be entirely replaced by the artificial product. But where is the public to obtain pure apple vinegar of acceptable quality? It is not for sale at the local groceries except in sealed bottles at twenty-five cents a quart. Beside it on the shelf may be found the distilled vinegar, artificially colored with caramel, and the white pickling vinegar at fifteen cents a bottle. In bulk the distilled vinegar can be bought for forty cents the gallon with a reliable guarantee behind it for strength and quality. But you say, [Page 4] "Surely you must be mistaken about not being able to get cider vinegar from your grocer in bulk." No, gentle reader, do not be deceived by the stencil mark on the end of the barrel. If, perchance, this particular lot came from a nearby ranch, the odds are in favor of its not being worth carrying home. Do not understand me to speak thus lightly of all home-made vinegar for there is some to be found of splendid quality, but it is the exception. As a rule the storekeeper will apologize to the customer for his farm vinegar, but with that which comes from the wholesale dealer it is different. Most certainly a sad condition, when the first and best vinegar that was ever made came from the farm home! What is more, it cannot be obtained from the farmer or apple grower today for most of them are buying all of the vinegar they use.

What has become of our apple vinegar industry, and why have the merchants turned their attention to the distilled article? The answer to this can be had without pursuing an extensive investigation into the economics of the question. It is simply this—the average run of farm vinegar is so inferior to the distilled product that the merchants cannot afford to handle it. The quality is so variable and the strength is so unreliable that the good housewife has learned through the repeated experience of having her pickles spoil not to ask for cider vinegar.

There is no good reason why this condition of affairs should exist which has resulted in placing a boycott on the farm product, but in the light of the facts as they actually exist, is not the consumer justified in taking this stand? There is no doubt that the synthetic article has come to stay, but this does not mean that genuine apple vinegar is a thing of the past. However, until we are able to produce as good or better vinegar on the farm and in the orchard and can guarantee its quality and strength to be reasonably constant, we have no right to ask or to expect the public to buy an inferior product or to help build up the industry by its patronage.

It is just as easy to make high-grade apple vinegar at home when one understands the different operations and principles involved as it is to make good butter or good bread. If the housewife knew as little about making butter and baking bread as the average farmer or orchardist knows about making vinegar, we should all forsake the staff of life and take refuge in the nearest sanitarium.

[Page 5]

Selection of the Apples.

What has been said above concerning second grade fruit for cider and vinegar is not to be construed as meaning rotten, wormy, dirty, or unripe fruit. Nothing is gained by such a practice and often all is lost. In the first place, it is impossible to cover up the flavor of the spoiled apples in the vinegar, and in the second place, when decayed and dirty fruit is employed, it is practically out of the question to control the fermentations in the cider upon which the quality of the finished product depends almost entirely.

There is no reason why apples which have merely been bruised should not be used, and where they are not too badly rotted, the soft portion can be cut out. Children are always glad to have a hand in cider making and this is just where their services will fit in nicely. Remember that many hands make light work and likewise clean, acceptable cider, and you will be surprised to see in how short a time the spoiled parts can be removed from the bushels of otherwise worthless apples.

The importance of washing the apples thoroughly with clean water before they go to the mill to be ground cannot be overestimated. There is bound to be a quantity of soil and dust clinging to the outside, particularly where the orchards lie along a public road and are clean cultivated so that the apples fall on plowed ground. This can be carried out very conveniently in an ordinary washtub, after which the apples should be allowed to drain before they are ground. One is always astonished at the amount of mud in the water after such an operation, even when relatively clean, hand-picked fruit is employed.

Let us see next whether all varieties of apples are equally well suited to cider vinegar making; whether a good cider apple is necessarily a good vinegar apple; and what constituent or constituents of the apple determine its usefulness for these different purposes.

In answer to the first question, it may be said that apples differ very widely in their adaptability to cider and vinegar making; some appear to have been created for this very purpose, while others would not do at all.

Concerning the second point, we find it is quite often the case that an apple which makes an excellent cider to drink would not make good vinegar. This is due to the fact that most tastes demand a cider that is not too sweet and with a slight acidity. Such [Page 6] apple juice would be very apt to make weak vinegar because of the relatively small amount of sugar present.

This reference to sugar brings us to the third item, namely, the important constituents of the apple so far as cider and vinegar are concerned. Several years ago, Dr. Van Slyke of the Geneva, N. Y., Experiment Station, reported a series of analyses of apple juices representing eighty-three different American-grown varieties. He gives the average composition of these juices as follows:

Solids

13.52 per cent

Total sugar as invert sugar

10.91 per cent

Ash

.29 per cent

Fixed acid (malic)

.52 per cent

The sugar is unquestionably the most important of these substances so far as the part which it plays in the making of cider vinegar since the degree of sourness due to the vinegar acid (acetic) is directly proportional to the fermentable sugar present; in other words, all of the acid which was not originally present in the cider as natural apple acid, or malic acid, is produced from the sugar by processes which are soon to be described. Therefore, since from a given amount of sugar just so much acid and no more can be made, we can understand quite readily that for a high grade vinegar of maximum acidity the apple juice containing the most sugar will be the most desirable. The amount of natural acid present in the juice plays an insignificant part in the final acidity of the vinegar, since the small quantity that is present in the apple juice practically all disappears during the change into vinegar. From this it is clear that it is the sugar and not the natural apple acid that is to be considered in cider for vinegar.

Now, as has been stated above, cider for table use is usually more pleasant to drink when it is not too heavy and when the sugar is lower and the acid somewhat higher than the standard for vinegar cider requires.

The composition of the juice of some of our common commercial varieties, especially the sugar content, may be of interest at this time in connection with what has been said with reference to the suitability of different ciders for vinegar making. The [Page 7] analyses which I am submitting are those given by Dr. Van Slyke[*] for eastern apples.

[*] Van Slyke, L, L., Bulletin 258, Geneva, N, Y., Exp. Sta. "A Study of the Chemistry of Home-Made Cider Vinegar," 1904.

Table I —— Analyses of Apple Juice of Different Varieties of American Apples.

Variety of Apple

Specific

Gravity

Solids.

Per cent.

Equivalent of total

sugar in form of

invert sugar.

Per cent.

Fixed

acid as

malic.

Per cent.

Baldwin

1.072

16.82

15.39

.67

Belleflower

1.061

14.09

12.82

.58

Ben Davis

1.052

12.77

10.60

.46

Ben Davis

1.046

10.69

6.74

.44

Gano

1.046

10.16

8.61

.41

Gano

1.056

13.92

11.32

.41

Grimes Golden

1.070

18.18

14.05

.74

Jonathan

1.056

14.62

11.60

.32

Maiden Blush

1.051

12.70

9.99

.67

Northern Spy

1.052

13.77

9.77

.69

Red Siberian Crab

1.070

17.34

11.83

.97

Rome Beauty

1.048

11.37

8.70

.37

Wealthy

1.057

15.26

11.64

.66

Whitney

1.060

14.16

11.39

.40

Winesap

1.065

16.45

13.34

.58

Yellow Transparent

1.049

11.71

9.76

.87

An examination of the above table shows us that there is a wide variation in the percentage of sugar in the apple juice of different varieties, varying from 6.74 per cent. in one sample of Ben Davis to 15.39 per cent. in the Baldwin; that the quantity of sugar in any given variety may vary as much as 4 per cent. (Ben Davis 6.74-10.60).

The amount of sugar depends upon a number of factors such as soil, climate, culture, variety, and ripeness, unripe and over-ripe apples containing less sugar than ripe ones.

[+] Browne has shown very clearly the changes that take place in the sugar content of apples at different periods of ripeness:

[+] Browne, Annual Rept. Penn. Dept. Agr, 1899. p. 541.

Table II —— Sugar in Baldwin Apple at Different Periods.

Date

Condition

Equivalent of Total Sugar in

Form of Invert Sugar.

Aug. 7, 1899

Very Green

8.11

Sept. 13, 1899

Green

10.72

Nov. 15, 1899

Ripe

14.87

Dec. 15, 1899

Over-ripe

14.85

The question is sometimes asked whether the so-called "sweet apples" will make as good vinegar as the tarter varieties. All things being equal, there is no reason why they should not, provided they contain as much sugar as the more acid kinds. This statement may seem somewhat paradoxical, but it should be remembered that [Page 8] it is the presence of acid rather than the absence of sugar that makes an apple taste sour. As a matter of fact, some of our very sourest sorts contain as much and more sugar than the sweetest sweet apples. Cider for vinegar should not contain less than 8.5 per cent. of sugar.

Storage of the Cider.

The most satisfactory containers for both cider and vinegar are whisky and brandy barrels. Molasses barrels and old vinegar barrels should be used only when no others are available, and then not until they have been very carefully and thoroughly cleaned. Too much stress cannot be laid upon the necessity of scalding old vinegar barrels with either live steam or boiling water to remove the last trace of the old vinegar. There is, perhaps, no one factor which is responsible for more failures in farm vinegar making than the time-honored but pernicious custom of using old vinegar barrels for sweet cider without even rinsing out the dregs of former years. Mere rinsing is not sufficient. They must be scalded to make them fit for use. If this is not done in such a manner as to kill all of the organisms in the barrel, the probability is that the sweet cider which is put in them subsequently will never make vinegar. The reason for this will be given a little later. In a recent number of a certain farm journal, the following is given under directions for making apple vinegar:

"Get a barrel in which good vinegar has been made and use it, or get some of the scum off of the top of good vinegar and rinse out the new barrels with this as soon as they cool after having been thoroughly washed out with boiling water. Put fresh cider into these barrels."

No procedure more absurd and dangerous to the success of apple vinegar could possibly be undertaken than is contained in this recommendation. In fact, it would be difficult to find a better recipe for vinegar failures than this. Never, under, any consideration, put either "mother" or old vinegar into sweet cider. It is never safe to use metallic containers for holding cider even for an interval of a few hours, since the acid of the juice attacks the metal, dissolving a portion of it. Such cider, because of the metal in solution, might produce metallic poisoning in the person drinking it.

The sweet cider as it comes from the press may either be placed at once in barrels, which should not be filled more than two-thirds to three-fourths full, or if one has suitable wooden tubs or vats in a clean, cool place, it may be stored there for twelve to [Page 9] twenty-four hours to permit settling, after which it should be transferred to barrels. The bung should be left out and a loose stopper of cotton batting inserted in the hole to decrease evaporation and prevent dirt from falling in. The barrels should not be tightly stoppered until the vinegar contains at least 4.5 to 5.0 per cent. of acetic acid, at which time they should be filled entirely full and securely bunged. Throughout the entire period of vinegar making, the casks should be placed on their side and not on the end. This gives the cider a larger free surface exposed to the air, which is quite essential to rapid vinegar formation. It may be of some advantage in admitting air to bore a one and one-half inch hole in each end of the barrel along the upper edge. If this is done, the holes should be covered with fine wire gauze or two thicknesses of cheese cloth to exclude small vinegar flies.

The Alcoholic Fermentation.

A few days after the cider is put into the barrels, the characteristic frothing appears at the bung-hole. To use a common expression, "It is beginning to work." This indicates that the alcoholic fermentation, the first step in the vinegar making process, has begun, and the sugar of the apple juice is being converted into alcohol and carbon dioxide gas.

The first of these substances is too well known to need any further comment other than to state that it is this element of "hard" cider that gives it its intoxicating property. With carbon dioxide, many of us are not as well acquainted. It is this gas escaping from the fermenting cider that causes the frothing and likewise the foamy appearance of the bread sponge. It is this gas dissolved in the cider or in the carbonated drinks at the soda-water fountains that imparts to them the characteristic bite or tingle, and upon escaping from the stomach produces that peculiar sensation in the head and nose. Strangely enough, this same gas is the active principle of practically all chemical fire extinguishers.

Now, what is the exciting agent which starts up the fermentation in the bread sponge and in the sweet cider? In both cases it is the same: a microscopic organism, the yeast plant. In the one instance we add a yeast cake to the bread mixture; in the other we either trust to the wild yeasts of the air and the skin of the apples or following the more recent, approved method, we add a yeast cake or a pure culture of a yeast selected especially for this purpose.

To depend upon the wild yeasts of the air to accomplish the fermentation is too uncertain since many of them are able to [Page 10] convert only a small part of the sugar into alcohol, while others act so slowly that they are impracticable. Inasmuch as the percentage of acetic acid in the vinegar depends directly upon the amount of alcohol produced, it is very essential to secure as large a yield of alcohol as possible from the sugar present. This means converting all of the sugar into alcohol in the shortest time possible. The most satisfactory way of doing this is to add one cake of compressed yeast, stirred up in a little cooled, boiled water, to each five gallons of sweet cider. In place of this, one quart of liquid wine yeast, propagated from a pure culture, may be used for each thirty gallons of cider.

During the alcoholic fermentation, the cider should be kept at a temperature of 65 to 80 degrees F. Here is where many make the very serious mistake of putting their fresh cider into a cool cellar where the fermentation takes place entirely too slowly. If the cider is made in the fall, the barrels should be left out of doors for a while on the protected, sunny side of a building and kept warm, unless a regular vinegar-cellar, artificially heated, is at hand.

If yeast is added and the proper temperature is maintained, the alcoholic fermentation should be completed in six weeks to three months in place of seven to ten months as in the old fashioned way. Experiments along this line have shown that when yeast is added and a temperature of 70 degrees F. is held, the cider at the end of one month contained 7.25 per cent. of alcohol as against .11 per cent. when no yeast was used and the temperature was between 45 and 55 degrees F. Cider kept in a cellar at 45 to 55 degrees with no yeast added required seven months to make 6.79 per cent. of alcohol.

Temperature, alone, is an important factor as shown by an experiment wherein cider to which no yeast was added was held for three months at 70 degrees F. and yielded 6.41 per cent. of alcohol.

There is no question but that the time required for completing the alcoholic fermentation can be reduced at least one half by adding yeast and by maintaining the proper temperatures. By hastening this operation, the loss of alcohol by evaporation is reduced, and the acetic fermentation can be started that much sooner.

Theoretically, 100 parts of sugar should give 51 parts of alcohol and 49 parts of carbon dioxide gas. This figure has been shown by Browne to be a little high. In actual practice, 45-47 parts of alcohol from 100 parts of sugar is a fair average.

But why not add "mother" or vinegar to sweet cider or put [Page 11] sweet cider into an old vinegar barrel? Here is the reason: We have seen from what has gone before that alcohol is produced from the fermentation of the sugar. We shall soon learn that the acetic acid of the vinegar is formed from this alcohol. Now, in order to obtain the maximum amount of acetic acid, it is necessary to have as much alcohol as possible in the hard cider, and this can be obtained only by the complete conversion of all the sugar into alcohol and carbon dioxide gas. The complete destruction of the sugar can be accomplished only by the uninterrupted action of the yeast, and the presence of "mother" of vinegar by producing acetic acid interferes seriously with this fermentation. The yeast cells are either killed or their useful activity is checked long before all of the sugar has been changed into alcohol. This is the condition of a very large percentage of farm vinegar—just hard cider that will not and never will make vinegar. It means just this:

A small part of the sugar was made into alcohol and this alcohol was at once changed to acetic acid by the "mother" present; this acetic acid killed the yeast so that no more sugar could be changed to alcohol and no more alcohol being found, no more acetic acid could be made by the "mother." We have a weak, worthless something neither vinegar nor hard cider with considerable unfermented sugar still present and incapable of further fermentation because no yeast can develop in the weak acetic acid solution.

The Acetic Acid Fermentation.

The second step in vinegar making is the change of the alcohol of the hard cider into the acetic acid of the finished product. This is accomplished by the acetic acid germ, another microscopic plant still smaller than the yeast. In some peculiar way it is able to bring about a union between the alcohol of the hard cider and the oxygen of the air so that the alcohol is transformed into acetic acid and water.

As soon as the alcoholic fermentation, described in the preceding section, is completed, draw off the clear liquid, being very careful not to disturb the sediment in the barrel. Wash out the barrel thoroughly and replace the hard cider. It is believed that removing this sediment permits the acetic acid to form somewhat more quickly, and furthermore, the sediment may undergo decomposition and impart a disagreeable flavor to the cider. Again, these dregs may harbor living bacteria which either destroy acetic acid or interfere with its formation.

This done, we are now ready to introduce the acetic acid [Page 12] germs. This may be carried out in a number of different ways, but preferably by means of a pure culture of a desirable organism which has been selected because of its ability to produce strong acetic acid and to impart an agreeable flavor to the vinegar. In place of the pure culture starter, one may add two to four quarts of good cider vinegar containing more or less "mother" for each barrel. The introduction of a desirable organism is left to chance in this case. A serious objection to this latter method is that sometimes one introduces foreign organisms with the "mother" which may prove detrimental to the vinegar. The pure culture starter is free from this objection. On the whole, the indiscriminate use of "mother" alone is to be discouraged, since the popular idea of what constitutes "mother" is apt to be wrong. Pure "mother" is made up exclusively of acetic acid bacteria and is recognized as the thin, white, glistening, gelatinous membrane that forms on the surface of vinegar. It seldom becomes one sixteenth of an inch in thickness and should be translucent or white in color, It is entirely distinct from the thick, tough, dark brown, slipping, leathery masses which form in vinegar and are usually regarded as "mothy of vinegar." Such accumulations contain the acetic acid germ, in all probability, but in an impure state. In addition to this organism there may be present yeast cells and numerous bacteria which are positively harmful to the vinegar. Often these growths undergo decomposition and give the vinegar a flavor of rotten oranges. Again the germs present may cause the partial or complete loss of the acid, particularly if the barrels are not full and tightly stoppered. All things taken into consideration, the use of this sort of "mother" is a rather dangerous procedure.

With the acetic fermentation, as with the alcoholic, the higher temperatures favor the changes. Experimental work shows that hard cider to which no acetic acid bacteria were added other than those that came from the air, and kept at 65 degrees F., when six months old, contained 7.03 per cent. of acetic acid, while that held at 55 degrees F. showed only 3.63 per cent.

The addition of some kind of an acetic acid starter, either as a pure culture of the acetic organism or as good vinegar, hastens the fermentation and reduces appreciably the time required for making marketable vinegar.

For most satisfactory results we would recommend using the pure cultures and holding the vinegar at a temperature of 65 to 75 degrees F. Under these conditions, salable vinegar can be obtained in three to six months in place of two to three years, as is often [Page 13] the case. Theoretically, 100 parts of alcohol should give about 130 parts of acetic acid, but in actual practice this will probably fall below 120.

When the acetic acid has reached 4.5 to 5 per cent., fill the barrels as full as possible and cork tightly. In this way, contact of the air with the vinegar is cut off and the acetic acid organisms soon cease their activity. If this is not done and the acetic and other bacteria are allowed to develop indefinitely, there is apt to be a reverse reaction resulting in a partial or complete loss of the acetic acid. Such vinegar is, of course, worthless.

Clarification of Vinegar.

For those who desire an extra fancy product of extraordinary brightness, suitable for bottling, it will be necessary to subject the vinegar to a special process of clarification known as fining. According to Bioletti[*], the best results are obtained by using isinglass. This is employed at the rate of from one-half to three-fourths of an ounce of isinglass to each one hundred gallons of vinegar.

[*] Bioletti, Frederic T., Grape Vinegar, Bull. 227, California Exp. Sta., 1912.

"The isinglass is cut into small pieces and soaked for twelve to twenty-four hours in a little water containing acetic or tartaric acid equal in weight to the isinglass used. When thoroughly soft it is then rubbed several times through a fine sieve, gradually adding a little more water until a perfectly fluid liquid is obtained. This fluid is then well mixed with a little vinegar and thoroughly stirred into the cask. With some vinegars it is necessary to add a little tannin, from one-half to one-seventh the amount of the isinglass used. This tannin should be added at least twenty-four hours before the finings.

When the finings have settled and the vinegar is perfectly bright it is ready for bottling."

Pure Cultures for Vinegar Making.

Reference has been made above to the use of pure cultures, both yeast and acetic acid bacteria, for vinegar making. For a little more than one year, the Bacteriological Laboratory of the Colorado Experiment Station has been supplying these at fifty cents (50c) per set, post paid, sufficient for one barrel, to those who care to give them a trial. Full printed directions for their use are included. These cultures have been selected because of certain properties which they possess which make them especially suited to the vinegar industry. No guarantee, either expressed or [Page 14] implied, goes with the cultures, since it is not the purpose of the Experiment Station to exploit these products, but rather to distribute them at the cost of production for experimental purposes. Inasmuch as one of the cultures is to be added to the sweet cider, the set should be obtained a few days, not longer, before the cider is to be made.

Requests for cultures should be addressed to the Bacteriological Laboratory, Colorado Experiment Station, Fort Collins, Colorado, and should be accompanied by a remittance of fifty cents (50c).

Directions For Using Pure Cultures in Making Vinegar Preparation of Yeast Culture.

1. For each barrel of sweet cider, sterilize one two-quart Mason jar by washing thoroughly and boiling for five minutes in clean water.

2. Cover the top of the jar with a single layer of clean muslin or cheese cloth just removed from boiling water and secure it in place by a string tied about the neck of the can.

3. Select 6 or 8 medium sized ripe apples; pare and quarter or slice them; add one quart of water and boil till soft; strain liquid through clean cloth while hot into Mason jar, first removing the cloth covering from the top.

4. Make up the volume of liquid to approximately one quart with boiling water; add 4 tablespoonfuls of sugar and replace the cloth immediately.

5. When the liquid has cooled thoroughly, partly remove the cloth covering and add the contents of the culture bottle marked "Yeast." Replace the cloth. Just previous to opening the culture bottle, shake thoroughly and immerse the lip and cork only, ten second in boiling water. Do not touch the lip while removing cork.

6. Keep the jar in subdued light at a temperature of 75 degrees F. to 90 degrees F. After two to four days the foaming characteristic of alcoholic fermentation should appear.

7. After four to six days, add the entire contents of the yeast jar to the barrel of freshly made sweet cider. The barrel must not be more than two-thirds full; it should be placed on its side, and the bung-hole be left open, or, better, plugged loosely with a tuft of clean cotton batting.

8. Keep the barrel at 75 degrees F. to 85 degrees F.

[Page 15]

Preparation of Acetic Culture.

1. Three to four weeks after the yeast culture has been added to the cider prepare the Acetic Culture in precisely the same manner as described for the yeast in paragraphs 1 to 6 above. See that all of the culture is removed from the bottle; rinse with a little cooled boiled water if necessary. Do not shake the jar while the culture is developing.

2. By the end of one to two weeks, a white, gelatinous film or membrane should be visible on the surface of the liquid. This is a growth of acetic acid bacteria and constitutes the "Mother of Vinegar."

3. When this acetic membrane is well formed, which will require about two weeks, with a clean sliver of wood, previously dipped into boiling water, remove the membrane from the jar, but do not lay it down; pour the contents of the jar into the barrel of cider, now fermented, to which the yeast was added some five or six weeks before; next drop the sliver with the attached acetic film into the barrel through the bung-hole. The wood will serve to float the acetic membrane on the surface of the hard cider and thereby hasten its development by keeping it in contact with the air.

4. Keep the barrel at 65 degrees F. to 75 degrees F. till the vinegar has formed.

5. When vinegar of satisfactory quality has been obtained, in three to six months, draw off and store at a cool, even temperature in casks which are kept full and tightly bunged.

6. Both of these cultures can be propagated indefinitely by employing a small portion of the jar cultures in the same manner as the original bottle starters.

*** END OF THE PROJECT GUTENBERG EBOOK HOME-MADE CIDER VINEGAR ***

Updated editions will replace the previous one—the old editions will be renamed.

Creating the works from print editions not protected by U.S. copyright law means that no one owns a United States copyright in these works, so the Foundation (and you!) can copy and distribute it in the United States without permission and without paying copyright royalties. Special rules, set forth in the General Terms of Use part of this license, apply to copying and distributing Project Gutenberg™ electronic works to protect the PROJECT GUTENBERG™ concept and trademark. Project Gutenberg is a registered trademark, and may not be used if you charge for an eBook, except by following the terms of the trademark license, including paying royalties for use of the Project Gutenberg trademark. If you do not charge anything for copies of this eBook, complying with the trademark license is very easy. You may use this eBook for nearly any purpose such as creation of derivative works, reports, performances and research. Project Gutenberg eBooks may be modified and printed and given away—you may do practically ANYTHING in the United States with eBooks not protected by U.S. copyright law. Redistribution is subject to the trademark license, especially commercial redistribution.

START: FULL LICENSE

THE FULL PROJECT GUTENBERG LICENSE

PLEASE READ THIS BEFORE YOU DISTRIBUTE OR USE THIS WORK

To protect the Project Gutenberg™ mission of promoting the free distribution of electronic works, by using or distributing this work (or any other work associated in any way with the phrase “Project Gutenberg”), you agree to comply with all the terms of the Full Project Gutenberg™ License available with this file or online at www.gutenberg.org/license.

Section 1. General Terms of Use and Redistributing Project Gutenberg™ electronic works

1.A. By reading or using any part of this Project Gutenberg™ electronic work, you indicate that you have read, understand, agree to and accept all the terms of this license and intellectual property (trademark/copyright) agreement. If you do not agree to abide by all the terms of this agreement, you must cease using and return or destroy all copies of Project Gutenberg™ electronic works in your possession. If you paid a fee for obtaining a copy of or access to a Project Gutenberg™ electronic work and you do not agree to be bound by the terms of this agreement, you may obtain a refund from the person or entity to whom you paid the fee as set forth in paragraph 1.E.8.

1.B. “Project Gutenberg” is a registered trademark. It may only be used on or associated in any way with an electronic work by people who agree to be bound by the terms of this agreement. There are a few things that you can do with most Project Gutenberg™ electronic works even without complying with the full terms of this agreement. See paragraph 1.C below. There are a lot of things you can do with Project Gutenberg™ electronic works if you follow the terms of this agreement and help preserve free future access to Project Gutenberg™ electronic works. See paragraph 1.E below.

1.C. The Project Gutenberg Literary Archive Foundation (“the Foundation” or PGLAF), owns a compilation copyright in the collection of Project Gutenberg™ electronic works. Nearly all the individual works in the collection are in the public domain in the United States. If an individual work is unprotected by copyright law in the United States and you are located in the United States, we do not claim a right to prevent you from copying, distributing, performing, displaying or creating derivative works based on the work as long as all references to Project Gutenberg are removed. Of course, we hope that you will support the Project Gutenberg™ mission of promoting free access to electronic works by freely sharing Project Gutenberg™ works in compliance with the terms of this agreement for keeping the Project Gutenberg™ name associated with the work. You can easily comply with the terms of this agreement by keeping this work in the same format with its attached full Project Gutenberg™ License when you share it without charge with others.

1.D. The copyright laws of the place where you are located also govern what you can do with this work. Copyright laws in most countries are in a constant state of change. If you are outside the United States, check the laws of your country in addition to the terms of this agreement before downloading, copying, displaying, performing, distributing or creating derivative works based on this work or any other Project Gutenberg™ work. The Foundation makes no representations concerning the copyright status of any work in any country other than the United States.

1.E. Unless you have removed all references to Project Gutenberg:

1.E.1. The following sentence, with active links to, or other immediate access to, the full Project Gutenberg™ License must appear prominently whenever any copy of a Project Gutenberg™ work (any work on which the phrase “Project Gutenberg” appears, or with which the phrase “Project Gutenberg” is associated) is accessed, displayed, performed, viewed, copied or distributed:

This eBook is for the use of anyone anywhere in the United States and most other parts of the world at no cost and with almost no restrictions whatsoever. You may copy it, give it away or re-use it under the terms of the Project Gutenberg License included with this eBook or online at www.gutenberg.org. If you are not located in the United States, you will have to check the laws of the country where you are located before using this eBook.

1.E.2. If an individual Project Gutenberg™ electronic work is derived from texts not protected by U.S. copyright law (does not contain a notice indicating that it is posted with permission of the copyright holder), the work can be copied and distributed to anyone in the United States without paying any fees or charges. If you are redistributing or providing access to a work with the phrase “Project Gutenberg” associated with or appearing on the work, you must comply either with the requirements of paragraphs 1.E.1 through 1.E.7 or obtain permission for the use of the work and the Project Gutenberg™ trademark as set forth in paragraphs 1.E.8 or 1.E.9.

1.E.3. If an individual Project Gutenberg™ electronic work is posted with the permission of the copyright holder, your use and distribution must comply with both paragraphs 1.E.1 through 1.E.7 and any additional terms imposed by the copyright holder. Additional terms will be linked to the Project Gutenberg™ License for all works posted with the permission of the copyright holder found at the beginning of this work.

1.E.4. Do not unlink or detach or remove the full Project Gutenberg™ License terms from this work, or any files containing a part of this work or any other work associated with Project Gutenberg™.

1.E.5. Do not copy, display, perform, distribute or redistribute this electronic work, or any part of this electronic work, without prominently displaying the sentence set forth in paragraph 1.E.1 with active links or immediate access to the full terms of the Project Gutenberg™ License.

1.E.6. You may convert to and distribute this work in any binary, compressed, marked up, nonproprietary or proprietary form, including any word processing or hypertext form. However, if you provide access to or distribute copies of a Project Gutenberg™ work in a format other than “Plain Vanilla ASCII” or other format used in the official version posted on the official Project Gutenberg™ website (www.gutenberg.org), you must, at no additional cost, fee or expense to the user, provide a copy, a means of exporting a copy, or a means of obtaining a copy upon request, of the work in its original “Plain Vanilla ASCII” or other form. Any alternate format must include the full Project Gutenberg™ License as specified in paragraph 1.E.1.

1.E.7. Do not charge a fee for access to, viewing, displaying, performing, copying or distributing any Project Gutenberg™ works unless you comply with paragraph 1.E.8 or 1.E.9.

1.E.8. You may charge a reasonable fee for copies of or providing access to or distributing Project Gutenberg™ electronic works provided that:

- • You pay a royalty fee of 20% of the gross profits you derive from the use of Project Gutenberg™ works calculated using the method you already use to calculate your applicable taxes. The fee is owed to the owner of the Project Gutenberg™ trademark, but he has agreed to donate royalties under this paragraph to the Project Gutenberg Literary Archive Foundation. Royalty payments must be paid within 60 days following each date on which you prepare (or are legally required to prepare) your periodic tax returns. Royalty payments should be clearly marked as such and sent to the Project Gutenberg Literary Archive Foundation at the address specified in Section 4, “Information about donations to the Project Gutenberg Literary Archive Foundation.”

- • You provide a full refund of any money paid by a user who notifies you in writing (or by e-mail) within 30 days of receipt that s/he does not agree to the terms of the full Project Gutenberg™ License. You must require such a user to return or destroy all copies of the works possessed in a physical medium and discontinue all use of and all access to other copies of Project Gutenberg™ works.

- • You provide, in accordance with paragraph 1.F.3, a full refund of any money paid for a work or a replacement copy, if a defect in the electronic work is discovered and reported to you within 90 days of receipt of the work.

- • You comply with all other terms of this agreement for free distribution of Project Gutenberg™ works.

1.E.9. If you wish to charge a fee or distribute a Project Gutenberg™ electronic work or group of works on different terms than are set forth in this agreement, you must obtain permission in writing from the Project Gutenberg Literary Archive Foundation, the manager of the Project Gutenberg™ trademark. Contact the Foundation as set forth in Section 3 below.

1.F.

1.F.1. Project Gutenberg volunteers and employees expend considerable effort to identify, do copyright research on, transcribe and proofread works not protected by U.S. copyright law in creating the Project Gutenberg™ collection. Despite these efforts, Project Gutenberg™ electronic works, and the medium on which they may be stored, may contain “Defects,” such as, but not limited to, incomplete, inaccurate or corrupt data, transcription errors, a copyright or other intellectual property infringement, a defective or damaged disk or other medium, a computer virus, or computer codes that damage or cannot be read by your equipment.

1.F.2. LIMITED WARRANTY, DISCLAIMER OF DAMAGES - Except for the “Right of Replacement or Refund” described in paragraph 1.F.3, the Project Gutenberg Literary Archive Foundation, the owner of the Project Gutenberg™ trademark, and any other party distributing a Project Gutenberg™ electronic work under this agreement, disclaim all liability to you for damages, costs and expenses, including legal fees. YOU AGREE THAT YOU HAVE NO REMEDIES FOR NEGLIGENCE, STRICT LIABILITY, BREACH OF WARRANTY OR BREACH OF CONTRACT EXCEPT THOSE PROVIDED IN PARAGRAPH 1.F.3. YOU AGREE THAT THE FOUNDATION, THE TRADEMARK OWNER, AND ANY DISTRIBUTOR UNDER THIS AGREEMENT WILL NOT BE LIABLE TO YOU FOR ACTUAL, DIRECT, INDIRECT, CONSEQUENTIAL, PUNITIVE OR INCIDENTAL DAMAGES EVEN IF YOU GIVE NOTICE OF THE POSSIBILITY OF SUCH DAMAGE.

1.F.3. LIMITED RIGHT OF REPLACEMENT OR REFUND - If you discover a defect in this electronic work within 90 days of receiving it, you can receive a refund of the money (if any) you paid for it by sending a written explanation to the person you received the work from. If you received the work on a physical medium, you must return the medium with your written explanation. The person or entity that provided you with the defective work may elect to provide a replacement copy in lieu of a refund. If you received the work electronically, the person or entity providing it to you may choose to give you a second opportunity to receive the work electronically in lieu of a refund. If the second copy is also defective, you may demand a refund in writing without further opportunities to fix the problem.

1.F.4. Except for the limited right of replacement or refund set forth in paragraph 1.F.3, this work is provided to you ‘AS-IS’, WITH NO OTHER WARRANTIES OF ANY KIND, EXPRESS OR IMPLIED, INCLUDING BUT NOT LIMITED TO WARRANTIES OF MERCHANTABILITY OR FITNESS FOR ANY PURPOSE.

1.F.5. Some states do not allow disclaimers of certain implied warranties or the exclusion or limitation of certain types of damages. If any disclaimer or limitation set forth in this agreement violates the law of the state applicable to this agreement, the agreement shall be interpreted to make the maximum disclaimer or limitation permitted by the applicable state law. The invalidity or unenforceability of any provision of this agreement shall not void the remaining provisions.

1.F.6. INDEMNITY - You agree to indemnify and hold the Foundation, the trademark owner, any agent or employee of the Foundation, anyone providing copies of Project Gutenberg™ electronic works in accordance with this agreement, and any volunteers associated with the production, promotion and distribution of Project Gutenberg™ electronic works, harmless from all liability, costs and expenses, including legal fees, that arise directly or indirectly from any of the following which you do or cause to occur: (a) distribution of this or any Project Gutenberg™ work, (b) alteration, modification, or additions or deletions to any Project Gutenberg™ work, and (c) any Defect you cause.

Section 2. Information about the Mission of Project Gutenberg™

Project Gutenberg™ is synonymous with the free distribution of electronic works in formats readable by the widest variety of computers including obsolete, old, middle-aged and new computers. It exists because of the efforts of hundreds of volunteers and donations from people in all walks of life.

Volunteers and financial support to provide volunteers with the assistance they need are critical to reaching Project Gutenberg™’s goals and ensuring that the Project Gutenberg™ collection will remain freely available for generations to come. In 2001, the Project Gutenberg Literary Archive Foundation was created to provide a secure and permanent future for Project Gutenberg™ and future generations. To learn more about the Project Gutenberg Literary Archive Foundation and how your efforts and donations can help, see Sections 3 and 4 and the Foundation information page at www.gutenberg.org.

Section 3. Information about the Project Gutenberg Literary Archive Foundation

The Project Gutenberg Literary Archive Foundation is a non-profit 501(c)(3) educational corporation organized under the laws of the state of Mississippi and granted tax exempt status by the Internal Revenue Service. The Foundation’s EIN or federal tax identification number is 64-6221541. Contributions to the Project Gutenberg Literary Archive Foundation are tax deductible to the full extent permitted by U.S. federal laws and your state’s laws.

The Foundation’s business office is located at 809 North 1500 West, Salt Lake City, UT 84116, (801) 596-1887. Email contact links and up to date contact information can be found at the Foundation’s website and official page at www.gutenberg.org/contact

Section 4. Information about Donations to the Project Gutenberg Literary Archive Foundation

Project Gutenberg™ depends upon and cannot survive without widespread public support and donations to carry out its mission of increasing the number of public domain and licensed works that can be freely distributed in machine-readable form accessible by the widest array of equipment including outdated equipment. Many small donations ($1 to $5,000) are particularly important to maintaining tax exempt status with the IRS.

The Foundation is committed to complying with the laws regulating charities and charitable donations in all 50 states of the United States. Compliance requirements are not uniform and it takes a considerable effort, much paperwork and many fees to meet and keep up with these requirements. We do not solicit donations in locations where we have not received written confirmation of compliance. To SEND DONATIONS or determine the status of compliance for any particular state visit www.gutenberg.org/donate.

While we cannot and do not solicit contributions from states where we have not met the solicitation requirements, we know of no prohibition against accepting unsolicited donations from donors in such states who approach us with offers to donate.

International donations are gratefully accepted, but we cannot make any statements concerning tax treatment of donations received from outside the United States. U.S. laws alone swamp our small staff.

Please check the Project Gutenberg web pages for current donation methods and addresses. Donations are accepted in a number of other ways including checks, online payments and credit card donations. To donate, please visit: www.gutenberg.org/donate.

Section 5. General Information About Project Gutenberg™ electronic works

Professor Michael S. Hart was the originator of the Project Gutenberg™ concept of a library of electronic works that could be freely shared with anyone. For forty years, he produced and distributed Project Gutenberg™ eBooks with only a loose network of volunteer support.

Project Gutenberg™ eBooks are often created from several printed editions, all of which are confirmed as not protected by copyright in the U.S. unless a copyright notice is included. Thus, we do not necessarily keep eBooks in compliance with any particular paper edition.

Most people start at our website which has the main PG search facility: www.gutenberg.org.

This website includes information about Project Gutenberg™, including how to make donations to the Project Gutenberg Literary Archive Foundation, how to help produce our new eBooks, and how to subscribe to our email newsletter to hear about new eBooks.

Table of Contents

HOME-MADE CIDER VINEGAR

HOME-MADE CIDER VINEGAR By Walter G. Sackett.

Selection of the Apples.

Table I —— Analyses of Apple Juice of Different Varieties of American Apples.

Table II —— Sugar in Baldwin Apple at Different Periods.

Storage of the Cider.

The Alcoholic Fermentation.

The Acetic Acid Fermentation.

Clarification of Vinegar.

Pure Cultures for Vinegar Making.

Directions For Using Pure Cultures in Making Vinegar Preparation of Yeast Culture.

Preparation of Acetic Culture.

THE FULL PROJECT GUTENBERG LICENSE